Monopropellant rocket

Short description: Rocket that uses a single propellant with a catalyst

A monopropellant rocket (or "monochemical rocket") is a rocket that uses a single chemical as its propellant.

## Contents

* 1 Chemical-reaction monopropellant rockets
* 2 Solar-thermal monopropellant thrusters
* 3 New developments
* 4 See also
* 5 References
* 6 External links

## Chemical-reaction monopropellant rockets

For monopropellant rockets that depend on a chemical reaction, the power for the propulsive reaction and resultant thrust is provided by the chemical itself. That is, the energy needed to propel the spacecraft is contained within the chemical bonds of the chemical molecules involved in the reaction.

The most commonly used monopropellant is hydrazine (N

4, or H
2N–NH
2), a compound unstable in the presence of a catalyst and which is also a strong reducing agent. The most common catalyst is granular alumina (aluminum oxide, Al

3) coated with iridium. These coated granules are usually under the commercial labels Aerojet S-405 (previously made by Shell)[1] or W.C. Heraeus H-KC 12 GA (previously made by Kali Chemie).[2] There is no igniter with hydrazine. Aerojet S-405 is a spontaneous catalyst, that is, hydrazine decomposes on contact with the catalyst. The decomposition is highly exothermic and produces a 1,000 °C (1,830 °F) gas that is a mixture of nitrogen, hydrogen and ammonia. The main limiting factor of the monopropellant rocket is its life, which mainly depends on the life of the catalyst. The catalyst may be subject to catalytic poisoning and catalytic attrition which results in the catalyst failure. Another monopropellant is hydrogen peroxide, which, when purified to 90% or higher concentration, is self-decomposing at high temperatures or when a catalyst is present.

Most chemical-reaction monopropellant rocket systems consist of a fuel tank, usually a titanium or aluminium sphere, with an ethylene-propylene rubber container or a surface tension propellant management device filled with the fuel. The tank is then pressurized with helium or nitrogen, which pushes the fuel out to the motors. A pipe leads from the tank to a poppet valve, and then to the decomposition chamber of the rocket motor. Typically, a satellite will have not just one motor, but two to twelve, each with its own valve.

The attitude control rocket motors for satellites and space probes are often very small, 25 mm (0.98 in) or so in diameter, and mounted in groups that point in four directions (within a plane).

The rocket is fired when the computer sends direct current through a small electromagnet that opens the poppet valve. The firing is often very brief, a few milliseconds, and — if operated in air — would sound like a pebble thrown against a metal trash can; if on for long, it would make a piercing hiss.

Chemical-reaction monopropellants are not as efficient as some other propulsion technologies. Engineers choose monopropellant systems when the need for simplicity and reliability outweigh the need for high delivered impulse. If the propulsion system must produce large amounts of thrust, or have a high specific impulse, as on the main motor of an interplanetary spacecraft, other technologies are used.

## Solar-thermal monopropellant thrusters

A concept to provide low Earth orbit (LEO) propellant depots that could be used as way-stations for other spacecraft to stop and refuel on the way to beyond-LEO missions has proposed that waste gaseous hydrogen—an inevitable byproduct of long-term liquid hydrogen storage in the radiative heat environment of space—would be usable as a monopropellant in a solar-thermal propulsion system. The waste hydrogen would be productively utilized for both orbital stationkeeping and attitude control, as well as providing limited propellant and thrust to use for orbital maneuvers to better rendezvous with other spacecraft that would be inbound to receive fuel from the depot.[3]

Solar-thermal monoprop thrusters are also integral to the design of a next-generation cryogenic upper stage rocket proposed by U.S. company United Launch Alliance (ULA). The Advanced Common Evolved Stage (ACES) is intended as a lower-cost, more-capable and more-flexible upper stage that would supplement, and perhaps replace, the existing ULA Centaur and ULA Delta Cryogenic Second Stage (DCSS) upper stage vehicles. The ACES Integrated Vehicle Fluids option eliminates all hydrazine and helium from the space vehicle—normally used for attitude control and station keeping—and depends instead on solar-thermal monoprop thrusters using waste hydrogen.[4]

## New developments

NASA is developing a new monopropellant propulsion system for small, cost-driven spacecraft with delta-v requirements in the range of 10–150 m/s. This system is based on a hydroxylammonium nitrate (HAN)/water/fuel monopropellant blend which is extremely dense, environmentally benign, and promises good performance and simplicity.[5]

The EURENCO Bofors company produced LMP-103S as a 1-to-1 substitute for hydrazine by dissolving 65% ammonium dinitramide, NH4N(NO2)2, in 35% water solution of methanol and ammonia. LMP-103S has 6% higher specific impulse and 30% higher impulse density than hydrazine monopropellant. Additionally, hydrazine is highly toxic and carcinogenic, while LMP-103S is only moderately toxic. LMP-103S is UN Class 1.4S allowing for transport on commercial aircraft, and was demonstrated on the Prisma satellite in 2010. Special handling is not required. LMP-103S could replace hydrazine as the most commonly used monopropellant.[6]

## See also

* Hypergolic propellant
* Liquid-propellant rocket
* Mars Reconnaissance Orbiter
* Reaction wheel
* Nitrous oxide fuel blend

## References

1. ↑ Aerojet Rocketdyne (12 Jun 2003). "Aerojet Announces Licensing and Manufacture of Spontaneous Monopropellant Catalyst S-405". aerojetrocketdyne.com. http://ir.aerojetrocketdyne.com/releasedetail.cfm?releaseid=708514.
2. ↑ Wilfried Ley; Klaus Wittmann; Willi Hallmann (2009). Handbook of Space Technology. John Wiley & Sons. p. 317. ISBN 978-0-470-74241-9. https://books.google.com/books?id=5LBx4EmBix8C&pg=PA317.
3. ↑ Zegler, Frank; Bernard Kutter (2010-09-02). "Evolving to a Depot-Based Space Transportation Architecture". AIAA SPACE 2010 Conference & Exposition. AIAA. p. 3. http://www.ulalaunch.com/site/docs/publications/DepotBasedTransportationArchitecture2010.pdf. "the waste hydrogen that has boiled off happens to be the best known propellant (as a monopropellant in a basic solar-thermal propulsion system) for this task. A practical depot must evolve hydrogen at a minimum rate that matches the station keeping demands."
4. ↑ Zegler and Kutter, 2010, p. 5.
5. ↑ Jankovsky, Robert S. (July 1–3, 1996). "HAN-Based Monopropellant Assessment for Spacecraft". 32nd Joint Propulsion Conference. Lake Buena Vista, Florida: NASA. NASA Technical Memorandum 107287; AIAA-96-2863. https://ntrs.nasa.gov/archive/nasa/casi.ntrs.nasa.gov/19960048008_1996081001.pdf.
6. ↑ "High Performance Green Propulsion (LMP-103S)". https://www.ecaps.space/hpgp-performance.php.

## External links

* Technical Reports on Hydrogen Peroxide as a Monopropellant for Rockets
* USPAT 20090133788 Nitrous oxide fuel blend monopropellants

* v
* t
* e

Spacecraft propulsion

Chemical
rockets|

| State|

* Liquid-propellant rocket
* Solid-propellant rocket
* Hybrid-propellant rocket

|

Propellants|

* Liquid propellant
* Cryogenic
* Hypergolic
* Monopropellant
* Bipropellant
* Staged combustion cycle
* Expander cycle
* Gas-generator cycle
* Tap-off cycle
* Pressure-fed engine
* Pump-fed engine
* Electric-pump-fed engine
* Tripropellant

Electrical
thrusters|

| Electrostatic|

* Colloid thruster
* Ion thruster
* Gridded
* Hall-effect thruster
* Field-emission electric propulsion

|

Electromagnetic|

* Pulsed inductive thruster
* Magnetoplasmadynamic thruster
* Electrodeless plasma thruster

Electrothermal|

* Pulsed plasma thruster
* Helicon double-layer thruster
* Arcjet rocket
* Resistojet rocket
* VASIMR

Other|

* Atmosphere-breathing electric propulsion
* High Power Electric Propulsion
* MagBeam
* Mass driver

Nuclear
propulsion|

| Closed system|

* Direct Fusion Drive
* Nuclear electric rocket
* Nuclear thermal rocket
* Radioisotope
* Salt-water
* Gas core
* "Lightbulb"

|

Open system|

* Nuclear pulse propulsion
* Antimatter-catalyzed
* Pulsed nuclear thermal rocket‎
* Fusion rocket
* Bussard ramjet
* Fission-fragment rocket
* Fission sail
* Nuclear photonic rocket

Other|

* Anti-gravity
* Beam-powered propulsion
* Cold gas thruster
* Gravity assist
* Solar sail
* Electric sail
* Magnetic sail
* Solar thermal rocket
* Tethers
* Steam thruster

Spaceflight portal

pt:Foguete monopropulsor

0.00

(0 votes)

Original source: https://en.wikipedia.org/wiki/Monopropellant rocket. Read more

|

Retrieved from "https://handwiki.org/wiki/index.php?title=Engineering:Monopropellant_rocket&oldid=3251239"
*[v]: View this template
*[t]: Discuss this template
*[e]: Edit this template