Apollo (spacecraft)

Saturn V-launched payload that took men to the Moon

Complete Apollo spacecraft stack: launch escape system, command module, service module, Lunar Module, and spacecraft–LM adapter The Apollo 17 CSM seen in lunar orbit from the ascent stage of the Lunar Module

The Apollo spacecraft was composed of three parts designed to accomplish the American Apollo program's goal of landing astronauts on the Moon by the end of the 1960s and returning them safely to Earth. The expendable (single-use) spacecraft consisted of a combined command and service module (CSM) and an Apollo Lunar Module (LM). Two additional components complemented the spacecraft stack for space vehicle assembly: a spacecraft–LM adapter (SLA) designed to shield the LM from the aerodynamic stress of launch and to connect the CSM to the Saturn launch vehicle and a launch escape system (LES) to carry the crew in the command module safely away from the launch vehicle in the event of a launch emergency.

The design was based on the lunar orbit rendezvous approach: two docked spacecraft were sent to the Moon and went into lunar orbit. While the LM separated and landed, the CSM remained in orbit. After the lunar excursion, the two craft rendezvoused and docked in lunar orbit, and the CSM returned the crew to Earth. The command module was the only part of the space vehicle that returned with the crew to the Earth's surface.

The LES was jettisoned during launch upon reaching the point where it was no longer needed, and the SLA remained attached to the launch vehicle's upper stage. Two uncrewed CSMs, one uncrewed LM, and one crewed CSM were carried into space by Saturn IB launch vehicles for low Earth orbit Apollo missions. Larger Saturn Vs launched two uncrewed CSMs on high Earth orbit test flights, the CSM on one crewed lunar mission, the complete spacecraft on one crewed low Earth orbit mission, and eight crewed lunar missions. After conclusion of the Apollo program, four CSMs were launched on Saturn IBs for three Skylab Earth orbital missions and the Apollo-Soyuz Test Project.

## Command and service module

[edit]

Main article: Apollo command and service module

The major part of the Apollo spacecraft was a three-man vehicle designed for Earth orbital, translunar, and lunar orbital flight, and return to Earth. This consisted of a command module supported by a service module, built by North American Aviation (later North American Rockwell).

### Command module (CM)

[edit]

Apollo Command Module and its position on top of Saturn V

The command module was the control center for the Apollo spacecraft and living quarters for the three crewmen. It contained the pressurized main crew cabin, crew couches, control and instrument panel, Primary Guidance, Navigation and Control System, communications systems, environmental control system, batteries, heat shield, reaction control system to provide attitude control, forward docking hatch, side hatch, five windows, and a parachute recovery system. It was the only part of the Apollo/Saturn space vehicle that returned to Earth intact.

### Service module (SM)

[edit]

Apollo Service Module

The service module was unpressurized and contained a main service propulsion engine and hypergolic propellant to enter and leave lunar orbit, a reaction control system to provide attitude control and translational capability, fuel cells with hydrogen and oxygen reactants, radiators to dump waste heat into space, and a high gain antenna. The oxygen was also used for breathing, and the fuel cells produced water for drinking and environmental control. On Apollo 15, 16 and 17 it also carried a scientific instrument package, with a mapping camera and a small sub-satellite to study the Moon.

A major portion of the service module was taken up by propellant and the main rocket engine. Capable of multiple restarts, this engine placed the Apollo spacecraft into and out of lunar orbit, and was used for mid-course corrections between the Earth and the Moon.

The service module remained attached to the command module throughout the mission. It was jettisoned just prior to reentry into the Earth's atmosphere.

## Lunar Module (LM)

[edit]

Main article: Apollo Lunar Module

Apollo Lunar Module

The Apollo Lunar Module was a separate vehicle designed to land on the Moon and return to lunar orbit, and was the first true "spaceship" since it flew solely in the vacuum of space. It consisted of a descent stage and an ascent stage. It supplied life support systems for two astronauts for up to four to five days on the Apollo 15, 16 and 17 missions. The spacecraft was designed and manufactured by the Grumman Aircraft Company.

The descent stage contained the landing gear, landing radar antenna, descent propulsion system, and fuel to land on the Moon. It also had several cargo compartments used to carry, among other things: the Apollo Lunar Surface Experiment Packages ALSEP, the modularized equipment transporter (MET) (a hand-pulled equipment cart used on Apollo 14), the Lunar Rover (Apollo 15, 16 and 17), a surface television camera, surface tools, and lunar sample collection boxes.

The ascent stage contained the crew cabin, instrument panels, overhead hatch/docking port, forward hatch, optical and electronic guidance systems, reaction control system, radar and communications antennas, ascent rocket engine and propellant to return to lunar orbit and rendezvous with the Apollo Command and Service Modules.

## Spacecraft–lunar module adapter (SLA)

[edit]

Apollo spacecraft-to-LM adapter

The spacecraft–LM adapter (SLA), built by North American Aviation (Rockwell), was a conical aluminum structure that connected the service module to the Saturn S-IVB rocket stage. It also protected the LM, the service propulsion system engine nozzle, and the launch-vehicle-to-service-module umbilical during launch and ascent through the atmosphere.[1]

The SLA was composed of four fixed 7-foot-tall (2.1 m) panels bolted to the Instrument Unit on top of the S-IVB stage, which were connected via hinges to four 21-foot-tall (6.4 m) panels which opened from the top similar to flower petals.

The SLA was made from 1.7-inch-thick (43 mm) aluminum honeycomb material.[2] The exterior of the SLA was covered by a thin (0.03–0.2 in or 0.76–5.08 mm) layer of cork and painted white to minimize thermal stresses during ascent.[3]

The service module was bolted to a flange at the top of the longer panels, and power to the SLA multiply-redundant pyrotechnics was provided by an umbilical. Because a failure to separate from the S-IVB stage could leave the crew stranded in orbit, the separation system used multiple signal paths, multiple detonators and multiple explosive charges where the detonation of one charge would set off another even if the detonator on that charge failed to function.

One of the SLA panels on Apollo 7 did not fully open to the designed 45°.

Transposition of CSM, docking and extraction of LM

Adapter panels are jettisoned and the CSM is turned 180 degrees

The CSM docks with the LM and pulls it away from the Saturn V third stage.

Once in space, the astronauts pressed the 'CSM/LV Sep' button on the control panel to separate the CSM from the launch vehicle. Detonating cord was ignited around the flange between the SM and SLA, and along the joints between the four SLA panels, releasing the SM and blowing apart the connections between the panels. Dual-redundant pyrotechnic thrusters at the lower end of the SLA panels then fired to rotate them around the hinges at 30–60 degrees per second.

Apollo 7 did not carry a Lunar Module. A structural stiffener is used to provide sufficient stiffness of the SLA.

On all flights through Apollo 7, the SLA panels remained hinged to the S-IVB and opened to a 45-degree angle, as originally designed. But as the Apollo 7 crew practiced rendezvous with the S-IVB/SLA containing a dummy docking target, one panel did not open to the full 45 degrees, raising concern about the possibility of collision between the spacecraft and the SLA panels during docking and extraction of the LM in a lunar mission. Wally Schirra compared it to the "angry alligator" from Gemini 9. This led to a redesign using a spring-loaded hinge release system which released the panels at the 45-degree angle and pushed them away from the S-IVB at a velocity of about 5 mph (8 km/h), putting them a safe distance away by the time the astronauts pulled the CSM away, rotated it through 180 degrees, and came back for docking.

The LM was connected to the SLA at four points around the lower panels. After the astronauts docked the CSM to the LM, they blew charges to separate those connections and a guillotine severed the LM-to-instrument-unit umbilical. After the charges fired, springs pushed the LM away from the S-IVB, and the astronauts were free to continue their trip to the Moon.

### Specifications

[edit]

* Height: 28 ft (8.5 m)
* Apex diameter: 12 ft 10 in (3.91 m) Service module end
* Base diameter: 21 ft 8 in (6.60 m) S-IVB end
* Weight: 4,050 lb (1,840 kg)
* Volume: 6,700 cu ft (190 m3), 4,900 cu ft (140 m3) usable

## Launch escape system (LES)

[edit]

Pad abort test (2), showing pitch motor and launch escape motor in operation

See also: Apollo abort modes

The Apollo launch escape system (LES) was built by the Lockheed Propulsion Company. Its purpose was to abort the mission by pulling the CM (the crew cabin) away from the launch vehicle in an emergency, such as a pad fire before launch, guidance failure, or launch vehicle failure likely to lead to an imminent explosion.

The LES included three wires that ran down the exterior of the launch vehicle. If the signals from any two of the wires were lost, the LES would activate automatically.[4] Alternatively, the Commander could activate the system manually using one of two translation controller handles, which were switched to a special abort mode for launch. When activated, the LES would fire a solid fuel escape rocket and open a canard system to direct the CM away from, and off the path of, a launch vehicle in trouble. The LES would then jettison and the CM would land with its parachute recovery system.

If the emergency happened on the launch pad, the LES would lift the CM to a sufficient height to allow the recovery parachutes to deploy safely before coming in contact with the ground.

In the absence of an emergency, the LES was routinely jettisoned about 20 or 30 seconds after the launch vehicle's second-stage ignition, using a separate solid-fuel rocket motor manufactured by the Thiokol Chemical Company. Abort modes after this point would be accomplished without the LES. The LES was carried but never used on four uncrewed Apollo flights, and fifteen crewed Apollo, Skylab, and Apollo-Soyuz Test Project flights.

### Major components

[edit]

Apollo launch escape system components

Nose cone and Q-ball
The nose cone of the LES contained an array of 8 pressure-measuring pitot tubes in a structure known as the "Q-ball". These sensors were connected to the CM and Saturn launch vehicle guidance computers, allowing calculation of dynamic pressure (q) during atmospheric flight and also the angle of attack in the event of an abort.[5]
Q-ball cover
A styrofoam cover, removed a few seconds before launch, protected the pitot tubes from being clogged by debris.[6] The cover was split in half vertically and held together by a 2-inch (51 mm) rubber band. A razor blade was positioned behind the rubber band, pinched between the halves of the cover. A wire cable was connected to the top and bottom of the razor blade and to both halves of the cover. The cable was routed through a pulley on the hammerhead crane at the top of the launch umbilical tower (LUT) down to a tube on the right side of the 360-foot (110 m) level of the LUT. The cable was connected to a cylindrical weight inside a tube. The weight rested on a lever controlled by a pneumatic solenoid valve. When the valve was actuated from the Launch Control Center (LCC), the pneumatic pressure of 600 psi (4,100 kPa) GN2 (nitrogen gas) rotated the lever down allowing the weight to drop down the tube. The dropping weight pulled the cable, which pulled the blade cutting the rubber band, and the cable pulled the halves of the cover away from the launch vehicle. The apparent overengineering of this safety system was due to the fact that the launch escape system, which depended on the Q-ball data, was armed 5 minutes before launch, so retraction of the Q-ball cover was a life-critical part of a possible pad abort.
Canard assembly and pitch motor
These worked in combination to direct the CM off a straight path and to the side during an emergency. This would direct the CM off the flight path of an exploding launch vehicle. It would also direct the CM to land off to the side of any launch pad fire and not in the middle of it.
Launch escape motor
The main solid-fuel rocket motor inside a long tube, with four exhaust nozzles mounted under a conical fairing. This would pull the CM rapidly away from a launch emergency.
Tower jettison motor
A smaller solid fuel motor with two exhaust nozzles, mounted in the tube, above the escape motor. This jettisoned the entire Launch Escape System after it was no longer needed, sometime after second stage ignition.
Launch escape tower
A truss framework of tubes that attached the escape motor fairing to the CM.
Boost protective cover
A hollow conical fiberglass structure protecting the CM's parachute compartment and providing a smooth aerodynamic cover over the docking tunnel and probe. After erosion of the pilot's windows from the escape motor exhaust was discovered during early LES flight testing, an aft protective cover surrounding the CM's entire upper surface was added.

### Specifications

[edit]

* Length minus BPC: 32 ft 6 in (9.92 m)
* Length with BPC: 39 ft 5 in (12.02 m)
* Diameter: 2 ft 2 in (0.66 m)
* Total mass: 9,200 pounds (4,200 kg)
* Thrust, 36,000 ft: 147,000 pounds-force (650 kN)
* Thrust, maximum: 200,000 pounds-force (890 kN)
* Burn time: 4.0 seconds

### Abort tests

[edit]

* Pad Abort Test 1 – LES abort test from launch pad with Apollo boilerplate BP-6
* Pad Abort Test 2 – LES pad abort test of near Block-I CM with Apollo boilerplate B-23A
* Little Joe II – Four in-flight LES abort tests.

## Current locations of spacecraft

[edit]

The disposition of all command modules, and all unflown service modules is listed at Apollo command and service module#CSMs produced. All flown service modules burned up in the Earth's atmosphere at termination of the missions. The disposition of all lunar modules is listed at Apollo Lunar Module#Lunar modules produced.

## References

[edit]

1. ^ No CSM was carried on the Apollo 5 uncrewed LM flight, and an aerodynamic nose cone was fastened to the top of the SLA instead.
2. ^ NASA.gov
3. ^ Launius, Roger D. "Moonport, Ch20-3". Archived from the original on July 14, 2019. Retrieved October 11, 2016.
4. ^ "Apollo Launch Abort System Test" on YouTube
5. ^ "Apollo 16 Flight Journal: Day 1 Part One". Archived from the original on July 2, 2013. Retrieved October 11, 2016.
6. ^ NASA.gov

* North American Rockwell, 'Apollo Command Module News Reference', 1968.
* NASA TN D-7083: Launch Escape Propulsion Subsystem
* Apollo Operations Handbook Lunar Module Subsystems Data

## External links

[edit]

* NASA report JSC-03600 Apollo/Skylab ASTP and Shuttle Orbiter Major End Items, Final Report, March 1978; NASA report listing dispositions of all rockets and spacecraft used in the Apollo, Skylab, Apollo-Soyez Test Project and early shuttle missions, as of 1978.
* Apollo D-2 Proposal by General Electric, Encyclopedia Astronautica

* v
* t
* e

Apollo program hardware

Launch vehicles|

* Little Joe II
* Saturn I
* Saturn IB
* Saturn V

Launch vehicle
components|

* F-1 engine
* J-2 engine
* Instrument unit
* Launch Vehicle Digital Computer

Spacecraft|

* Apollo
* Apollo command module
* Columbia
* Apollo service module
* Apollo Lunar Module
* Eagle

Spacecraft
components|

* Apollo Abort Guidance System
* Apollo Docking Mechanism
* Apollo Guidance Computer
* Lunar Sounder Experiment
* Primary guidance, navigation, and control system
* Apollo Telescope Mount
* Apollo TV camera
* Descent propulsion system
* Ascent propulsion system
* Scimitar antenna

Space suits|

* Apollo/Skylab A7L
* Beta cloth
* Thermal Micrometeoroid Garment

Lunar surface
equipment|

* Portable Life Support System
* Lunar Roving Vehicle
* Lunar Laser Ranging experiment
* list of retroreflectors
* Solar Wind Composition Experiment
* Apollo Lunar Surface Experiments Package
* Active Seismic Experiment
* Apollo 12 Passive Seismic Experiment
* Apollo 14 Passive Seismic Experiment
* Charged Particle Lunar Environment Experiment
* Lunar Ejecta and Meteorites Experiment
* Solar Wind Spectrometer Experiment
* Modular Equipment Transporter
* Lunar Seismic Profiling Experiment
* Lunar Surface Gravimeter
* Lunar Surface Magnetometer
* Lunar Traverse Gravimeter
* Cold Cathode Gauge Experiment
* Heat Flow Experiment
* Suprathermal Ion Detector Experiment

Ground support|

* Mobile Launcher
* Launch Umbilical Tower
* Crawler-transporter
* Lunar Landing Research Vehicle
* Mobile quarantine facility

Ceremonial|

* Lunar plaque
* Lunar Flag Assembly
* Fallen Astronaut
* Apollo 11 goodwill messages

Related|

* Lunar escape systems
* Rendezvous Docking Simulator
* Moon Museum

Category:Apollo program hardware

* v
* t
* e

Apollo program

* List of missions
* canceled missions
* List of Apollo astronauts

Launch complexes|

* Launch Complex 34
* Launch Complex 37
* Launch Complex 39
* A
* B

Ground facilities|

* Mission Control Center
* Cape Kennedy Air Force Station
* Crawler-transporter
* Kennedy Space Center
* Manned Space Flight Network

Launch vehicles|

* Little Joe II
* Saturn
* Saturn I
* Saturn IB
* Saturn V

Spacecraft and rover|

* Apollo spacecraft
* Command and Service Module
* Lunar Module
* Lunar Roving Vehicle

Flights|

| Uncrewed|

* AS-101
* AS-102
* AS-201
* AS-202
* Apollo 4
* Apollo 5
* Apollo 6†

|

Crewed|

* Apollo 1†
* Apollo 7
* Apollo 8
* Apollo 9
* Apollo 10
* Apollo 11
* Apollo 12
* Apollo 13†
* Apollo 14
* Apollo 15
* Apollo 16
* Apollo 17

Saturn
development|

* Saturn-Apollo 1
* SA-2
* SA-3
* SA-4
* SA-5
* AS-203
* Apollo 4
* Apollo 6†

Abort tests|

* QTV
* Pad Abort Test-1
* A-001
* A-002
* A-003
* Pad Abort Test-2
* A-004

Pegasus flights|

* AS-103
* AS-104
* AS-105

Apollo 8 specific|

* Earthrise
* Genesis reading

Apollo 11 specific|

* Command Module Columbia
* Lunar Module Eagle
* Tranquility Base
* Double crater
* Little West crater
* Goodwill messages
* Lunar sample displays
* Missing tapes
* Anniversaries
* 50th Anniversary commemorative coins
* In popular culture

Apollo 12 specific|

* Statio Cognitum
* Surveyor 3
* Surveyor crater
* Bench Crater meteorite
* J002E3
* Moon Museum
* Reports of Streptococcus mitis on the Moon

Apollo 13 specific|

* "Houston, we've had a problem"

Apollo 14 specific|

* Modular Equipment Transporter
* Fra Mauro formation
* Big Bertha
* Moon tree

Apollo 15 specific|

* Journey
* Lunar operations
* Solo operations
* Return to Earth
* Hadley–Apennine
* Fallen Astronaut
* Genesis Rock
* Great Scott
* Hadley Rille meteorite
* Seatbelt basalt
* Postal covers incident

Apollo 16 specific|

* Big Muley

Apollo 17 specific|

* The Blue Marble
* Taurus–Littrow
* Tracy's Rock
* Nansen-Apollo crater
* Shorty crater
* Lunar sample display
* Lunar basalt 70017
* Troctolite 76535
* Apollo Lunar Sounder Experiment
* Fe, Fi, Fo, Fum, and Phooey

Post-Apollo
capsule use|

* Skylab
* 2
* 3
* 4
* Apollo–Soyuz

Related|

* Lunar orbit rendezvous
* Stolen and missing Moon rocks
* Third-party evidence for Apollo Moon landings

* Symbol † indicates failure or partial failure

* v
* t
* e

NASA

Policy and history|

| History
(creation)|

* NACA (1915)
* National Aeronautics and Space Act (1958)
* Space Task Group (1958)
* Paine (1986)
* Rogers (1986)
* Ride (1987)
* Space Exploration Initiative (1989)
* Augustine (1990)
* U.S. National Space Policy (1996)
* CFUSAI (2002)
* CAIB (2003)
* Vision for Space Exploration (2004)
* Aldridge (2004)
* Augustine (2009)

|

General|

* Space Race
* Administrator and Deputy Administrator
* Chief Scientist
* Astronaut Corps
* Ranks and positions
* Chief
* Budget
* NASA research
* spinoff technologies
* NASA+
* NASA TV
* NASA Social
* Launch Services Program
* Mercury Control Center
* Manned Space Flight Network
* Kennedy Space Center
* Vehicle Assembly Building
* Launch Complex 39
* Launch Complex 48
* Launch Control Center
* Operations and Checkout Building
* Johnson Space Center
* Mission Control
* Lunar Sample Laboratory
* Science Mission Directorate

Human spaceflight
programs|

| Past|

* X-15 (suborbital)
* Mercury
* Gemini
* Apollo
* Skylab
* Apollo–Soyuz (with the Soviet space program)
* Space Shuttle
* Shuttle–Mir (with Roscosmos)
* Constellation

|

Current|

* International Space Station
* Commercial Orbital Transportation Services
* Commercial Crew
* Orion
* Artemis
* Lunar Gateway

Robotic programs|

| Past|

* Hitchhiker
* Mariner
* Mariner Mark II
* MESUR
* Mars Surveyor '98
* New Millennium
* Lunar Orbiter
* Pioneer
* Planetary Observer
* Ranger
* Surveyor
* Viking
* Project Prometheus
* Mars Exploration
* Mars Exploration Rover

|

Current|

* Living With a Star
* Lunar Precursor Robotic Program
* Earth Observing System
* Great Observatories program
* Explorers
* Voyager
* Discovery
* New Frontiers
* Solar Terrestrial Probes
* Commercial Lunar Payload Services
* SIMPLEx

Individual featured
missions
(human and robotic)|

| Past|

* Apollo 11
* COBE
* Mercury 3
* Mercury-Atlas 6
* Magellan
* Pioneer 10
* Pioneer 11
* Galileo
* timeline
* GALEX
* GRAIL
* WMAP
* Space Shuttle
* Spitzer Space Telescope
* Sojourner rover
* Spirit rover
* LADEE
* MESSENGER
* Aquarius
* Cassini
* Dawn
* Kepler space telescope
* Opportunity rover
* timeline
* observed
* RHESSI
* InSight
* Ingenuity helicopter
* flights

|

Currently
operating|

* Mars Reconnaissance Orbiter
* 2001 Mars Odyssey
* New Horizons
* International Space Station
* Hubble Space Telescope
* Chandra X-ray Observatory
* Swift
* THEMIS
* Mars Exploration Rover
* Curiosity rover
* timeline
* GOES 14
* Lunar Reconnaissance Orbiter
* GOES 15
* SDO
* Juno
* Mars Science Laboratory
* timeline
* NuSTAR
* Voyager 1
* Voyager 2
* MAVEN
* MMS
* OSIRIS-APEX
* TESS
* Mars 2020
* Perseverance rover
* timeline
* James Webb Space Telescope
* timeline
* PACE
* Europa Clipper

Future|

* NISAR
* Nancy Grace Roman Space Telescope
* DAVINCI
* VERITAS

Communications
and navigation|

* Near Earth Network
* Space Network
* Deep Space Network (Goldstone
* Madrid
* Canberra
* Space Flight Operations Facility)
* Deep Space Atomic Clock

NASA lists|

* Astronauts
* by name
* by year
* Gemini astronauts
* Apollo astronauts
* Space Shuttle crews
* NASA aircraft
* NASA missions
* uncrewed missions
* Apollo missions
* Space Shuttle missions
* United States rockets
* NASA cancellations
* NASA cameras on spacecraft

NASA images
and artwork|

* Earthrise
* The Blue Marble
* Family Portrait
* Pale Blue Dot
* Pillars of Creation
* Mystic Mountain
* Solar System Family Portrait
* The Day the Earth Smiled
* Fallen Astronaut
* Deep fields
* Lunar plaques
* Pioneer plaques
* Voyager Golden Record
* Apollo 11 goodwill messages
* NASA insignia
* Gemini and Apollo medallions
* Mission patches
* Astronomy Picture of the Day
* Hubble Space Telescope anniversary images

Related|

* "We choose to go to the Moon"
* Apollo 8 Genesis reading
* Apollo 15 postal covers incident
* Apollo Lunar Module
* Space Mirror Memorial
* The Astronaut Monument
* Lunar sample displays
* Moon rocks
* stolen or missing
* U.S. Astronaut Hall of Fame
* Space program on U.S. stamps
* Apollo 17 Moon mice
* Moon tree
* Other primates in space
* NASA International Space Apps Challenge
* Astronauts Day
* National Astronaut Day
* Nikon NASA F4

* Category
* Commons

* v
* t
* e

Crewed spacecraft (programs)

Active|

* China
* Shenzhou
* Russia
* Soyuz
* United States
* Crew Dragon
* Starliner
* New Shepard

Retired|

* Soviet Union
* Vostok
* Voskhod
* Buran
* United States
* X-15
* Mercury
* Gemini
* Apollo
* Command and service module
* Apollo Lunar Module
* Space Shuttle
* SpaceShipOne
* SpaceShipTwo

In development|

* China
* Mengzhou
* Lanyue
* India
* Gaganyaan
* Russia
* Orel
* United States
* Orion
* Starship
* Starship HLS
* Blue Moon
* Dream Chaser

Cancelled|

* United States
* SpaceShip III

*[BPC]: Boost Protective Cover
*[v]: View this template
*[t]: Discuss this template
*[e]: Edit this template