Table of Contents Categories
  Encyclosphere.org ENCYCLOREADER
  supported by EncyclosphereKSF

Crusher (robot)

Topic: Engineering

 From HandWiki - Reading time: 4 min
Crusher
ManufacturerDARPA
Year of creation2006[1]
Derived fromSpinner[1]

Crusher is a 13,200-pound (6,000 kg)[2] autonomous off-road Unmanned Ground Combat Vehicle developed by researchers at the Carnegie Mellon University's National Robotics Engineering Center for DARPA.[3] It is a follow-up on the previous Spinner vehicle.[1] DARPA's technical name for the Crusher is Unmanned Ground Combat Vehicle and Perceptor Integration System,[4] and the whole project is known by the acronym UPI, which stands for Unmanned Ground Combat Vehicle PerceptOR Integration.[3]

Capabilities

The robot can travel over rough terrain, such as vertical walls more than 4 feet (1.2 m) high,[2] wooded slopes, and rocky creekbeds.[5] It can turn 180 degrees in place, raise and lower its suspension by 30 inches (76 cm), more than one-half the 49.5 inches (126 cm) diameter of the wheels,[2] and lean to the side.[5] The Crusher can carry 8,000 pounds (3,600 kg) of combined armor and cargo.[2] According to Stephen Welby, director of DARPA's Tactical Technology Office, "This vehicle can go into places where, if you were following in a Humvee, you'd come out with spinal injuries."[6] The Crusher can see enemy troops from over 2 miles (3.2 km) away with its cameras.[6] The Crusher can climb up slopes of more than 40 degrees and travel with more than 30 degrees of slope to the side. When pushed to its maximum speed, the Crusher can travel at 26 miles per hour (42 km/h), but it can only sustain that speed for less than seven seconds.[2]

Construction

These robots have space frames (made of aluminum and titanium) and skid plates[5] to protect the robot from heavy blows from objects like boulders.[2] The Crusher also has a hybrid engine[2][7] capable of travelling several miles on one battery charge. The diesel engine then turns on to continue powering the Crusher and to recharge the battery module.[7] This diesel engine comes from a diesel Volkswagen Jetta.[6]

Controls

The Crusher has no driving controls because it is autonomous.[5] Instead, the operators drive the Crusher with video game controllers.[6] While driving between its waypoints via GPS, the Crusher continuously attempts to find the fastest and easiest path to its destination. For example, if it encounters an object more than 6 feet (1.8 m) high or a gorge more than 6 feet (1.8 m) deep, the Crusher will find a way around it.[8]

The camera system uses five 1.9 megapixel color cameras, which give an overall field of view of 200 degrees horizontally and 30 degrees vertically at a resolution of over four times that of a normal television set. Currently, the Crusher sends data back to an operator via a 0.62 miles (1 km) long 0.063 inches (1.6 mm) wide fiber-optic cable.[9]

Purpose

The Crusher could be used for a number of missions considered highly dangerous for soldiers, such as fire support, reconnaissance, or medevac; as a supply mule; or as a sentry.[5] John Bares, one of the people on the development team for the Crusher, mentions that medevac would be a good use for the robot because it could go into the battlefield under fire to scoop up fallen soldiers.[10] There are no plans to put the Crusher vehicle into service. Instead, it will be used as the base for future unmanned vehicle designs.[11]

See also

  • Autonomous robot
  • List of military vehicles
  • Multifunctional Utility/Logistics and Equipment

References

  1. ↑ 1.0 1.1 1.2 "Crusher Unmanned Ground Combat Vehicle Unveiled" (PDF) (Press release). Defense Advanced Research Projects Agency. April 28, 2006. Archived from the original (PDF) on 12 January 2011. Retrieved 18 November 2010.
  2. ↑ 2.0 2.1 2.2 2.3 2.4 2.5 2.6 "UPI: UGCV PerceptOR Integration" (PDF) (Press release). Carnegie Mellon University. Archived from the original (PDF) on 16 December 2013. Retrieved 18 November 2010.
  3. ↑ 3.0 3.1 "Carnegie Mellon's National Robotics Engineering Center Unveils Futuristic Unmanned Ground Combat Vehicles" (PDF) (Press release). Carnegie Mellon University. April 28, 2006. Archived from the original (PDF) on 22 September 2010. Retrieved 18 November 2010.
  4. ↑ Sharkey, Noel. "Grounds for Discrimination: Autonomous Robot Weapons". RUSI: Challenges of Autonomous Weapons: 87. Archived from the original on 28 September 2011. https://web.archive.org/web/20110928105846/http://www.rusi.org/downloads/assets/23sharkey.pdf. Retrieved 18 November 2010. 
  5. ↑ 5.0 5.1 5.2 5.3 5.4 Gibbs, W. Wayt (May 15, 2006). "A New Robot Rolls, and a New Prize Is Set". Scientific American. http://www.scientificamerican.com/article.cfm?id=a-new-robot-rolls-and-a-n&page=1. Retrieved 18 November 2010. 
  6. ↑ 6.0 6.1 6.2 6.3 "Pentagon's "Crusher" Robot Vehicle Nearly Ready to Go". Fox News. February 27, 2008. http://www.foxnews.com/story/0,2933,332755,00.html. Retrieved 18 November 2010. 
  7. ↑ 7.0 7.1 "Crusher Description". Carnegie-Mellon University. http://www.rec.ri.cmu.edu/projects/crusher/description/. Retrieved 18 November 2010. 
  8. ↑ Shane III, Leo (February 25, 2008). "They call him the Crusher". Stars and Stripes. http://www.stripes.com/news/they-call-him-the-crusher-1.75461. Retrieved 18 November 2010. 
  9. ↑ Ross, Bill; Bares, John; Jackel, Larry; Perschbacher, Mike (2008). "An Advanced Teleoperation Testbed". Field and Service Robotics. Springer Tracts in Advanced Robotics. 42. pp. 278–304. doi:10.1007/978-3-540-75404-6_28. ISBN 978-3-540-75403-9. https://hal.inria.fr/inria-00272962/file/fsr_100.pdf. 
  10. ↑ Eagan, James (September 5, 2006). "Crusher Robot". ScienCentral. Archived from the original on 7 August 2011. https://web.archive.org/web/20110807065556/http://www.sciencentral.com/articles/view.php3?article_id=218392846&cat=3_4. Retrieved 19 November 2010. 
  11. ↑ DARPA’s Crusher Drives Itself, Laughs at Your Puny “Traffic” - Gizmodo.com, March 13, 2012

External links



Retrieved from "https://handwiki.org/wiki/index.php?title=Engineering:Crusher_(robot)&oldid=3263151"
Licensed under CC BY-SA 3.0 | Source: https://handwiki.org/wiki/Engineering:Crusher_(robot)
275 views | Status: cached on July 13 2024 19:14:16
↧ Download this article as ZWI file
Encyclosphere.org EncycloReader is supported by the EncyclosphereKSF